Since then I have replace the spark plugs, wires, and coil. I have power to cluster, all lights work fine, horn is strong. You will want to do a good and thorough job so the bike will continue to work properly. Your carburetor has a very important job to perform and if things are blocking it from doing its job, your bike will not run. If not, then you will have to test further. It won t start when hot but runs fine otherwise. Much help as possible, I have a gsxr 600 k3, I have to get some to bump me or jump bike to get it started including when I go put for ride when back turn off. Bike sat for 21 years, inside a buddies garage. Getting compression. Advice ? I bought new spark plug, new fuses, electrical seemed good. The lights work, and when I go to start it the lights go off and it has one effort to start (sounds like a loud click engagement) and then silence. I unplugged the fuel line from the tank and cranked the bike, fuel came out. Once the bike fires on the starting fluid, it will usually help draw the gas through the fuel system. Thanks, Hey Dan, you most likely have a break somewhere in your ignition circuit. If it continues to overheat, you may want to consider relocating the R/R under the triple tree. Hey Brandon, does it seem like the fuel is being pumped? Sounds like a fuse or an electrical gremlin. Can they fail..under load? What do I do please help. Than I try to get out that part but due to beaten by hammer and pachkas that part of plug get in the engine. helo. Suzuki Intruder flasher relay. Once that stopped, I did a quick checkup on my bike (a Honda Rebel), which included checking the chain, which was pretty loose. If I turn the bike off. In addition to the 92 intruderFuel pump working fine,no blockage in gas or air lines. After a jump start, ran great and for few next days. Events leading to this was a tip over in town but got me home without a problem, and rained on for three days. Need help. If it is, run a test and make sure that you are actually getting spark. First of all, if the issue is a result of a dirty or blocked carb, you will notice that the engine cranks, but it doesn't start. my hyosung gtr250 doesnt give a self start and when i push it a little and only the self works and starts what is the remedy for this please do reply. Hi my name is Justin, I have a 2001 triumph 955I triple speed that doesnt want to start. Also read that the ignition timing doesnt go off on CDI bikes.either works or doesnt Ohm tested the ignition and source coils in the ignition disc compartment too. You can try a new spark plug, the spark may not be strong enough. So since then I have purchased a new battery.and. They just did the 8k service and new spark plugs before they sold it. The bike is turning over with seemingly full power but wont catch. Im not sureif that goes bad (Id guess your battery just wont charge properly..? Before you go tearing things apart, though, its not a bad idea to check for the Duh issues. Im having an issue with 96 kawasaki vulcan 800 classic please help! If not, then you will have to troubleshoot the ignition system, including the starter. what i do now sir, please kindly reply my question. Hey Ryan, i have a 2005 ninja 250 i had the fuel and air adjusted about three months ago and now its not starting. When I install charged air filter bike wont start. by keltec Fri Oct 18, 2013 1:24 pm, #2 Made sure the kill switch was off and fuse was good Hi, Im having the same problem and done everything I can do plz help me I have a 2000 Suzuki katana and turns over start then shuts off after I take the jumper cables off. It died while driving it just shut off. Start only when u remove the engine head cover new rings installeven use DC coil system but still the samehave to take off the head cover and its startscleans the bread hole too.same thingeasy advice ???? Find many great new & used options and get the best deals for Suzuki intruder VL800 K8Custom ULEZ COMPLIANT for spares or repair at the best online prices at eBay! When my friend and I started taking things apart, I saw that there was a long hairline crack on the cylinder head. It was very clean and I didn't muck with the jets. It cools down and starts well with all the same readings? Bike has been sitting over winter, I dont know if be a new battery sort it or stator. You should do a compression test its not very hard to do. Doing a good job on your cleaning is very important. Then I drained the oil and it was full of gas. Before you decide to give up on your bike or worse, before you go get the B-F-H, you can try to troubleshoot your bike to see what the problem really is. What could be causing this issue? I have an 02 gaze 1000 that would start fine. Motorcycle been stop for about a year. Heres the fun part, fuel gets to the carbs, a lot of it. link to 6 Reasons Why Your Motorcycle Accelerates By Itself. Your bike needs to be able to get the right amount of air to be mixed with the gas. Your bike will usually still run rough if these are bad, but you can visually inspect them fairly fast. The only thing that came on was the headlight. We adjusted the float heights a good bit. Hey, check to make sure the main fuse is not blown. The simplified wiring harness I made for my 1996 VS1400. You are using an out of date browser. You can also run a leak test to be sure you do not have any air leaks. Ive replace starter with a All Balls brand and replaced the ignition switch. Scooter not starting !!! But failing something simple like a dead battery or loose connection, your 1500LC probably needs the new stator assembly. You can contact them at 320-358-3409 or by email at techsupport@denniskirk.com. Am i headed in the right dirrection? Please help. With no fuel, the engine will not run at all. I also coat the spring. Or maybe the Air/Fuel ratio is messed up. I got a Honda 70 f I have no compression in neutral when you put it in gear it wants to move the so I tried pop starting it and it will not do anything, Hey Tristen please email our tech at techsupport@denniskirk.com. link to Can A Loose Motorcycle Chain Cause Vibration. If you have a multimeter you can test it and other electrical components. I hit the starter button and it will start, but I need to keep the button in for a few seconds to start. What next? Ive got a 2001 Yamaha 600r and its been sitting for a couple of years. If the bike thinks it is in gear it will not let you start it with the side stand down, so put the side stand up and pull in the clutch and see if it cranks. glenn, Either you got a new battery that does not have enough cold cranking amps or you need a new starter motor! Any help?? Half turn like a dead battery or. Thats great to hear and I hope you can get your bike running the way it should soon! I have to wait for a couple of minutes before it starts again. Apr 21, 2014 2001 Suzuki VS 1400 Intruder. If you have access to spare coils, you can try swapping parts or you can test the parts with a load tester. You are fucking awesome dude. Ryan suggested that I call their tech advice hotline. Hey Matt, the float or needle is most likely stuck. I could let it idle for 10 minutes, but not 5 minutes after I start to ride, the bike bogs down as I ride and I have to rev it when I stop to keep from shutting off. This will help to get the really tricky stuff off. A broken or loose vacuum line can result in too much air being drawn into the combustion chamber, which will alter the air/fuel mixture and not allow the engine to ignite the mixture properly. But since he said there was a dead battery issue. but we notice the light on parking plug is not much. I would look a little more into the neutral . The lights come on, but nothing when trying to start. Just checked your parts. This bike has only 29 miles on it. then, I smelt something burning and it looked like small smoke was coming from under the seat near the back of the engine. Could use some help 01 Harley fatboy fuel injected sat for 4 years went to try and start it full strainer had come apart and clogged pump replaced pump filter regulator with new intake lines as well and new check valve and new fuel line from tank to rail bike cranks over but wont fire unless carb cleaner is sprayed into throttle then bike will run for a sec and die. These may sound like no brainers, but if you go to doomsday mode right away (which many of us do), you can easily overlook the simple things. I sprayed the ignition switch with contact cleaner thinking maybe it was gummed up, but still nothing. So, thats weird. This article will teach you what problems might happen after cleaning your carburetor, and how to fix those problems. Hey Jon this sounds like a frustrating situation. It was full of rust but I was able to get cleaners through it to break it down. Make sure that your key is turned to On or Run and that the kill switch is in the Run position as well. it tries to turn over but wont catch. Fergus. Turn the ignition key on, but don't try to start engine, the voltage should be about the same 12.2 ish volts ,If a sharp drop is seen when key is turned suspect duff battery or needs charging. now bike wont start .. Compression tested too. I ment I made it carbureted. took the carb off gave it a good clean checked the float and everything in the carb checked, checked the filter in the tank, checked the gas pipe clear, checked for a spark and got a good. So, why exactly might your motorcycle not start after cleaning the carbs? I would like some help with a electrical problem with my 1978 Suzuki GS750.I found it in a barn its been sitting for 13 years. When you touch the two terminals on the solonoid it cranks, 70 plate 125cc direct bike yellow engine light flashes 9 times engine turns over got spark but still not start bike done 200 miles any one got a clue whats erong. Bad battery connection? Free delivery for many products! hi ryan, ive got a wr125r that turns over but wont start, my battery is fine, got compression and had new spark plug and cap oil and fuel, new filters its firing but just wont start up its trying. I need some advice anything will help. However after a warm up, it hesitates about 2 minutes into the ride. As Statorshave wound wiringIm fairly sure they can fail,,,,but maybe still test within specbike sitting still. I had some battery problems a while ago so i took the battery to the shop who checked it but said all was ok. What could be wrong? Half turn like a dead battery or bad connection or loose ground? Hey Breeze. Does it crank over, or is everything dead? The air box is off. Once they are removed, turn off the choke and turn the motor over until the excess gas has dissipated or if you have time, you can just let the bike sit until it evaporates. For help troubleshooting, feel free to contact our tech team at 320-358-3409 or by email at techsupport@denniskirk.com. Please help, it looks like they just made it yesterday. The bike is fuel injected. It wont turn over at all. Ran the new battery down trying to start it,,was g ona try and find some new plugs tomorrow,and I have the battery in charge now! It sounds like a fuel delivery problem. A mechanic buddy.saidtake them outnot the problem, I did.still cant solve this. What might be the issue? And bucks and stumbles. No turning over or anything. The bike turns on, lights and all, but when I hit the start button it doesnt fire up something also sounds different. Hey I have a buell blast it will turn over but shut right back off and when I spray some starter fluid it will start but want stay on for long. I have a 1987 Yamaha FZ 600. It has spark and the compression seems okay (about 110psi cold). And it did start. What do you think? With choke in, will only run with a bit of throttle,let go she dies. Suzuki intruder won't start? Now they are telling me that it is the cdi conversation unit. And when I was purchassing it from the owner it had a dead battery so we. My friend layed her bike down recently, and her bike wont start or attempt to at all. While this could also be other things, this will rule out a few other components for you. Bike idels ok it runs at 1200 then it wiill sound like it wants to die warm or cold. Think this is culpeit. Fuel lines can dry out and crack. i have a mt125 and having a problem starting it. Hey man. Like u said i replaced it with a substitute starter motor. For a better experience, please enable JavaScript in your browser before proceeding. Hi Ryan, I have 2007 Yamaha Royal Star TD. Infinity Sports. I just dont understand could you help me. Does it not turn over at all? Contact us:speedyautocc@outlook.com Make sure that the gas tank is vented properly. Secondly, you will want to make sure that you do not have any air leaks. Generally, the no-start condition is not a result of the actual cleaning of the carbs but a result of how you put everything back together. One thing at a time. He loves restoring motorcycles, has a vast knowledge of how they work, and has sold his restoration projects to customers from all over the United States. Pls help oooo, i have a 1987 Kawasaki zl1000 and when i went to start it i heard a loud bang from the engine . Thanks for your help. work,not fuses. Just turn your key on and you will hear the fuel pump kick in. Where to start. I flick on the fuel switch and i can here fuel pump in. Runs on starting fluid until it burns off. Please help. Replaced stater rectifier n battery due to faulty wires. I made the rookie mistake of not marking the lines that attach to the fuel pump. 02:07 - Source: CNN. Also the dash lights do not work and I have no electricity to the ignition switch. It still may be the battery. Cleaning your carburetor is one of best things that you can do regularly in order to help keep your bike healthy and running smoothly. Your motorcycle might not start after cleaning the carburetor because you may have put the float back together upside down. To check the compression, you will need a compression tester. Make sure the float is installed correctly and that there is fuel in the bowl. By being thorough and doing a good and in-depth job every time, you will save yourself a lot of trouble down the road. Not starting. Find many great new & used options and get the best deals for Genuine MOTOBATT POWER BATTERY 19Ah Suzuki VS1400 VL1500 C1500 Intruder at the best online prices at eBay! Thanks again. Ive got a carb issue. Whats wrong with my bike? Once warned up it runs fine. It will take a minute before the necessary vacuum pull has formed again and fuel is flowing through the carb. Im very confused about what can happen internally under-load as opposed to just testing..OHMs and AC voltagenot under-load.in gear..bike weight and rider weight. Spark plugs are good, new charged battery. Green light came on saying was charged so I tried starting bank. Check your fuses first. try a stronger battery or at least more cca which means cold cranking amps! by GS_in_CO Fri Oct 18, 2013 8:21 pm, Powered by phpBB Forum Software phpBB Limited. I have a 1981 Husky WR250 (2-stroke) that will not start. So, today I bought a new battery and tried to start up bike again. Could you see light through the pilot jets when you cleaned the carbs? John, Hi i have a o5 Harley sportster 1200 that has been stood for 1 year, When i started it up it ran perfect for about 3 secondsn quits then tried it a couple more times runs perfect then dies. I tested my stator as per your technical supports suggestion. Essentially, their Can A Loose Motorcycle Chain Cause Vibration? My bike turns over and over and does not start. Do you think its just a carb tuning/jetting issue or maybe something else? Is it possible the injectors are clogged as well. Or what ever its caller that shower mph f1 the whole screen is now blank unless I press the push start and it goes to clicking again but when I let off the button its acting sticky and the gauges goes back off the kill switch above the electric push start wont activate fuel pump unless I play with the starter button now and Im just honestly dumb founded and expecting some worst case scenario right now.. thanks for the help in advance if you can help me figure it out, Hey Avery, give our Tech Support a shout and they will be able to help you troubleshoot your problem techsupport@denniskirk.com, I have a problem with my 2002 kawasaki ninja zx6r e10. If youre still having some issues after you go through the carbs, feel free to contact our tech team to help troubleshoot further. Seems that gas is not making it to the McCooney carb or once gas makes it to the carb it still wont fire. Made it back home with same problem. Required fields are marked *. You also can run a compression test on your engine. Motorcycle Repair: Suzuki intruder wont start, intruder 250, eric gorr. New ignition switch on order. Now with new battery it wont even light up when you turn on key. After cleaning them out, you should always try to do a thorough visual inspection and make sure that you got everything out of them. Suzuki intruder wont start. Again, started for a second and died. If you cannot see any gunk in any of them, then you did a good job. Honda xr125L. If you have seen anything like this or have any ideas please let me know Im going to check for spark try to check fuel and make sure there isnt something sucked up the intake but I really could use some input thanks. I can jump start it off my van with jumper leads. Drove bike in shop and parked it, bike hasnt started since. Hi Sasank, Ill need a little more info to help you on that. Description: VS800 Intruder :Experience a true cruiser. Thank you! any idea what this could be? I havent ridden in around 4 months-hope you can help. Unread post Its not fuel injected and it wasnt a terrible fall. Remember that your bike needs four main things to run. Hey Robert, is the new battery charged with all wires connected back up? We will be able to dig deeper into troubleshooting and faster through these channels than we can in these comments. I have rebuilt carbs (2nd set actually, my mechanic buddy thought something was wrong with the set I had), all the seals been redone, new o-rings, float sets, float needles, floats, diaphragms are supple, not tears or pin holes, all passages cleaned and cleanedthey are nice. Problem of no power after 9000 rpms (in Neutral) and under 8500 in 1st.under 8000 in 2nd and struggling to reach even 6500 rpms in 3rd. Dirty carb ?? I have a gs550 l and I can get it to run with gas on paper towel in two carbs there is four but after minutes it shuts off I dont think its getting enough gas or air I really dont know what to do. by NorthernPete Fri Oct 18, 2013 5:40 pm, #4 Hi I just plug the charger wrong color in the motorcycle to help the battery to start the bike but after I turn the start switch on to start the bike the bike shut off no light or any thing. Just an idea if sat all night in the rain ,could be an electrical fault. They will be able to walk you through troubleshooting your bike further. I gave stripped the carbs and clesnex, new oil and plugs. Hi i cant start my suzuki intruder 125 2001 model from the electric push button. Still will only turn over but not start. I just purchased a 2010 Suzuki GZ250 and it was running well for a month. Make sure the cables are operating smoothly as well. Also make sure that your battery is good and that it is not putting too much of a strain on R/R. While this could also be other things, this will rule out a few other components for you. i put a new battery in the bike. Now it won't start, the electric start kicks but nothing. Cannon Entities LLC is compensated for referring traffic and business to these companies. Been running fine so far,,but iIve just owned it for about a week,,,It does need a good tuneup,it sat for awhile before I bought it! Does this mean i need to flood and clean my gas tank? Sorry so long just very anxious. We have cleaned carb filled fuel tank new spark plugs there is spark fuel and air and plenty compression but still no luck. sincerely, Lee. Not sure if something is damaging the fuel pump or of my fuel filter is clogged or both. and some petrol poured on the engine and then floor. Sitting for long periods of time can also dry out your fuel system. Checking the simplest things first will save you time down the road. 2014 Harley Breakout. I also voltage tested and it showed nothing out of the ordinary. I dont hear the typical sound of it firing, any suggestions? Now his bike wont start. And as im righting this i M checking. I started the bike on the lift (not sure why) and it started. 2003 HD FLHTCUI bike ran fine . Reversing the charger could blow the fuse. You can also take a brush and use that to scrub the parts while they are soaking in the container.

Can You Pass Inspection With Maintenance Light On, Female Religious Congregation In Nigeria, Andrea Butera Cnn Age, Suzuki Intruder Wont Start, Articles S